1.受紙箱廠原紙堆放時間影響
1. Affected by the stacking time of base paper in carton factory
卷筒紙?jiān)趥}庫長時間堆放會造成原紙纖維疲勞，造成耐破下降。原紙如果在倉庫中堆放時間超過3個月，其耐破值會下降5~8%；如果堆放時間超過6個月，耐破強度損失將達到10%以上。
The long-term stacking of web paper in the warehouse will cause the fatigue of base paper fiber and reduce the burst resistance. If the base paper is stacked in the warehouse for more than 3 months, its bursting value will decrease by 5 ~ 8%; If the stacking time exceeds 6 months, the loss of bursting strength will reach more than 10%.
2.原紙纖維
2. Base paper fiber
原紙的耐破強度主要由它本身的纖維決定。耐破度與纖維長度和纖維間的結合力有關，纖維長度增加，纖維間結合力增大，都使耐破度提高。此外，在抄造原紙的過程中適當加入一些助劑也有助于提高原紙的耐破強度。
The bursting strength of base paper is mainly determined by its own fiber. The burst resistance is related to the fiber length and the binding force between fibers. With the increase of fiber length and the binding force between fibers, the burst resistance is improved. In addition, proper addition of some additives in the process of making base paper also helps to improve the bursting strength of base paper.
3.與紙板本身的含水量有關
3. It is related to the moisture content of the paperboard itself
紙板水份含量在5%~6%時，耐破值大。水份含量8~14%范圍內變化時，耐破值變化不超過5%，但水份含量達到18%時耐破值下降幅度可達10%左右。也就是說瓦楞紙箱在相對濕度為50%RH～80%RH的環境存放，其耐破強度變化幅度很小，因此可以免去試樣溫濕平衡處理過程，從而大大縮短測試時間。
When the moisture content of paperboard is 5% ~ 6%, the bursting value is the largest. When the moisture content changes within the range of 8 ~ 14%, the change of bursting value does not exceed 5%, but when the moisture content reaches 18%, the bursting value decreases by about 10%. In other words, when the corrugated box is stored in the environment with relative humidity of 50% RH ~ 80% RH, the change range of bursting strength is very small. Therefore, the temperature and humidity balance treatment process of the sample can be avoided, so the test time can be greatly shortened.
4.與本身材質有關
4. Related to its own material
瓦楞紙箱的耐破強度由構成紙板之內層、外層及中隔原紙本身的耐破強度決定，與瓦楞芯紙無關。
The bursting strength of corrugated box is determined by the bursting strength of the inner layer, outer layer and spacer base paper, which has nothing to do with corrugated core paper.
5.受紙箱廠儲藏環境影響
5. Affected by the storage environment of carton factory
原紙或者瓦楞紙箱存貯環境以25 ± 5℃，55 ± 5%RH環境為宜。
The storage environment of base paper or corrugated box should be 25 ± 5 ℃ and 55 ± 5% RH.
以上就是瓦楞紙箱廠給大家分享關于瓦楞紙箱耐破強度的所有內容。
The above is all about the bursting strength of corrugated boxes shared by corrugated box factory.
本文由
紙箱廠家友情奉獻.更多有關的知識請點擊:
http://flyconn.cn我們將會對您提出的疑問進行詳細的解答，歡迎您登錄網站留言.
This article is dedicated by carton manufacturers. For more information, please click: http://flyconn.cn We will answer your questions in detail. You are welcome to log in to the website and leave a message
